新闻资讯
网站首页 > 新闻资讯 >

浙大中控DCS卡件使用前应充分了解注意事项

2022-06-25 00:27:02 来源:http://www.sdjkyqyb.com/ 53

说到中控DCS卡件的操作,不少人都比较关心应该从哪儿认识了解起来,如果出现问题又该怎么办呢?下面我们从使用的注意事项开始了解起来。
When it comes to the operation of the central control DCS card, many people are concerned about where to learn and what to do if there is a problem? Let's start with the precautions for use.
当中控DCS卡件系统出现停电时,应立即将系统中投入自动控制的回路切到手动。当供电正常时,检查系统运行及系统数据是否正常,如果有异常现象,重新下传组态,并检查核对系统参数。一切正常后方可再次投入自动。
In case of power failure in the central control DCS card system, the circuit in the system that is put into automatic control shall be switched to manual immediately. When the power supply is normal, check whether the system operation and system data are normal. If there is any abnormal phenomenon, download the configuration again, and check and verify the system parameters. After everything is normal, it can be put into automatic again.
启动运行上电顺序:UPS、控制站、显示器、操作站计算机。停机次序:控制站计算机、显示器、控制站、UPS。
Startup, operation and power on sequence: UPS, control station, display and operation station computer. Shutdown sequence: control station computer, display, control station and UPS.
操作员口令维护:每台操作站上的操作员口令之间无任何关系,必须单独建立。口令是保证系统安全正常运行的前提,必须严格执行。
Operator password maintenance: there is no relationship between operator passwords on each operating station, which must be established separately. Password is the premise to ensure the safe and normal operation of the system and must be strictly enforced.
历史数据保存在操作站硬盘上,与系统停电等因素无关。历史数据是追查事故责任的重要手段。操作站计算机是系统的重要组成部分,必须保持其正常运行和整洁。
The historical data is stored on the hard disk of the operation station and has nothing to do with system power failure and other factors. Historical data is an important means to trace accident liability. The operation station computer is an important part of the system and must be kept in normal operation and tidy.
浙大中控DCS卡件
当系统卡件故障时应把相应控制回路立即切回手动,并通知DCS系统维护人员立即更换故障卡件,检查确认故障消除时方可再次将系统投入自动。
When the system card fails, the corresponding control circuit shall be switched back to manual immediately, and the DCS system maintenance personnel shall be notified to replace the failed card immediately. The system can be put into automatic again only after the fault is checked and confirmed to be eliminated.
自动控制过程中,出现变送器故障,应立即切回手动。如果出现阀门故障现象,此时应切回手动,改为现场操作。系统出现断电,此时应立即切回手动,并要求工程师检查系统情况,确认完好后方可再次投入自动。
In case of transmitter failure during automatic control, switch back to manual mode immediately. In case of valve failure, switch back to manual operation and change to field operation. In case of power failure of the system, the system shall be switched back to manual mode immediately, and the Engineer shall be required to check the system condition, and the system can be put into automatic mode again after confirmation.
操作界面数据不刷新(正常情况数据每秒刷新一次),手自动切换无法操作等情况,应联系仪表人员进行维护。同时立即到现场操作。
If the data on the operation interface is not refreshed (under normal conditions, the data is refreshed every second), and the manual and automatic switching cannot be operated, contact the instrument personnel for maintenance. At the same time, go to the site for operation immediately.
出现系统卡件故障时应把相应控制回路切回手动,并由仪表人员更换故障卡件,检查确认故障消除后方可再次投入自动。
In case of system card failure, the corresponding control circuit shall be switched back to manual mode, and the instrument personnel shall replace the failed card. After checking and confirming that the failure is eliminated, it can be put into automatic mode again.
浙大中控DCS卡件系统出现异常断电,应改为手动操作。重新上电后,要求工程师检查系统情况,检查回路参数等系统数据是否正常,确认各调节阀的开度。一切正常后方可再次投入自动。
In case of abnormal power failure in the DCS card system of Zheda central control, it should be changed to manual operation. After power on again, the engineer is required to check the system condition, check whether the loop parameters and other system data are normal, and confirm the opening of each regulating valve. After everything is normal, it can be put into automatic again.
以上便是问题的相关解答内容了,如果您想获取更多相关信息,就来关注我们网站http://www.sdjkyqyb.com吧!
The above is the relevant answers to the questions. If you want to get more relevant information, please follow our website http://www.sdjkyqyb.com Come on!
产品推荐
新闻推荐